当前位置:首页-新闻动态 > 行业资讯 >

彩钢瓦你知道该怎么安装吗?

来源:http://www.jnqkgjg.com 日期:2019-01-11 发布人:admin

1. 放样:依图面及现场实测尺寸进行放样(隔墙中心线)以两收边中心线与地上的交点弹出地轨中

1. Lofting: Lofting according to the figure surface and field measured size (partition center line) and popping out of the ground track at the intersection of the two side centerlines and the ground.
心线。应确保这四条线处在一个笔直面内,以确保以后装置之墙面的笔直。
The heart line. It should be ensured that the four lines are in a straight plane to ensure that the wall of the later device is straight.
2. 天轨:装置要规整,接口处须补强修齐,每隔500mm—600mm击钉或螺丝固定于水泥天花板。
2. Skyway: The device should be regular, the interface should be repaired and fixed to the cement ceiling every 500mm-600mm bolt or screw.
3. 地轨:装置地轨时要先把门的装置方位预留,需要留意地差问题。如地上凹凸差太多,须整平使
3. Ground Rail: When installing the ground rail, the orientation of the door should be reserved, and the ground difference should be noticed. If there is too much difference between concave and convex on the ground, it must be leveled.
其落差减少,不影响调整水平,每隔600mm以击打或螺丝固定地坪上,如果地缝太大以填缝剂补满。
Its drop decreases, does not affect the adjustment level, every 600 mm to hit or screw fixed on the floor, if the floor seam is too large to fill with sealant.
4. 收边:依据实际测量值切开收边,切开后边际修齐。力求规整共同,衔接处要求无缝隙。与天轨及踢脚板接口处尤其留意,更要做到无缝隙。
4. Edge closing: According to the actual measured value, cut the edge and trim the edge after cutting. Strive for common regularity and seamless joints. Special attention should be paid to the joints with the skyline and the kickboard, and seamless should be achieved.
5. 竖向龙骨:每隔49cm置一支竖向龙骨(为隔板尺寸的一半),门框两边立柱上下彻底固定,不致
5. Vertical keel: A vertical keel (half of the size of the partition) is placed every 49cm, and the columns on both sides of the door frame are completely fixed.
于摇晃,反方向增加一支竖向龙骨,门扇宽度超越90cm以上,门框上横立柱有必要加强固定,必要时以焊接固定之。
When shaking, a vertical keel is added in the opposite direction, and the width of the door fan exceeds 90 cm. It is necessary to strengthen and fix the horizontal column on the door frame, and to fix it by welding if necessary.
6. 横向穿心龙骨:增高超越3米以上,以笔直方向1.2米置一支,当连两支衔接处有必要堆叠,堆叠
6. Cross-core keel: Increase the height over 3 meters, set one in a straight direction of 1.2 meters, when two connecting points need to be stacked, stacked.
长度不得少于10cm。
The length shall not be less than 10 cm.
商河彩钢厂
7. 墙板:由一侧开端装置彩钢板,顺次装置,相连板距离12mm。隔板之间选用宽度12mm压条,
7. Wallboard: Colored steel plate is installed at the beginning of one side, sequential device, and the distance between connecting plates is 12 mm. The width of the strip is 12 mm.
标准单元墙板均可互换
Standard cell wall panels are interchangeable
留意事项
Points for attention
1、墙板装置尤其留意细节,首先用托板车把墙板运至装置点邻近,使用吸盘将金属板直立,下端靠在踢脚板上,衬板两边紧靠竖向龙骨,单边与另一片墙板距离12mm以固定件靠上,用自攻螺丝固定于竖向龙骨上,固定距离300mm—400mm之间,拼装时须留意水平及笔直,当到达后一块墙板须裁切时,有必要以尺寸丈量过,按正确方法裁切修齐,装置于墙面上。
1. Wallboard device pays special attention to details. First, the wallboard is transported to the installation point by pallet truck. The metal plate is upright with sucker, the lower end is on the kickboard, the two sides of the lining board are close to the vertical keel, the distance between one side and another wallboard is 12 mm, and the fixing part is on the vertical keel with self-tapping screw. The fixing distance is 300 mm-400 mm. When assembling, attention should be paid to the horizontal and vertical. When a wallboard has to be cut after arrival, it is necessary to measure the size too much, cut and trim in the correct way, and install it on the wall.
2、墙体转角收边阴角由“U”型阴角收边条收边处理。
2. The corner edge closure of the wall is handled by the U-shaped corner edge closure bar.
3、为达到全体作用美观大方,角落以及柱子可选用工厂量身定做的定尺彩钢板。
3. In order to achieve all the functions of beauty and generosity, factory-tailored fixed-length color steel plate can be selected for corners and pillars.
4、墙体角落选用同色专业收边,使角落与墙面保持共同。
4. Choose the same color professional edge closure in the corner of the wall to keep the corner and the wall together.
以上信息是我们商河彩钢厂整理发布希望对大家以后的生活带来一点帮助我们的网站是:http://www.jnqkgjg.com
The above information is that our Shanghe Color Steel Works organize and publish the hope to bring you a little help in the future life of our website is: http://www.jnqkgjg.com!