当前位置:首页-新闻动态 > 常见问题 >

将磁漆喷涂在彩钢瓦上要注意什么

来源:http://www.jnqkgjg.com 日期:2019-05-06 发布人:admin

  对刚生产的彩钢瓦进行喷涂,一是为了让它的色泽艳丽,在建筑中起到装饰作用,二是通过涂料,保护它的外表,延长它的使用寿命,除了正确将磁漆喷涂在瓦上,还要注意喷涂的几点事项:

  To spray the newly produced color steel tile, one is to make it bright in color and play a decorative role in the building, the other is to protect its appearance and prolong its service life by coating. In addition to correctly spraying the paint on the tile, some matters needing attention are also included in the spraying process:
  一、正确的喷涂方法
  1. Correct Spraying Method
  1、喷涂磁漆,采用喷枪,配能够自动调压的空压机。
  1. Spraying paint, using spray gun, equipped with air compressor which can automatically regulate pressure.
  2、局部修补和小面积施工,不具备喷涂条件时可用普通油漆刷进行手工涂抹。
  2. Local repairing and small area construction. If the spraying conditions are not met, ordinary paint brushes can be used for manual painting.
  3、磁漆的搅拌与配比,运到现场的瓷漆涂料,添加醇酸稀料后,进行适当的搅拌。
  3. The mixing and proportion of enamel paint, the enamel paint which is transported to the site, after adding alkyd dilute material, mix properly.
  4、严格按照应按说明书规定的配比进行现场调配,边调边用。
  4. In strict accordance with the proportions prescribed in the instructions, on-site dispatching should be carried out while dispatching.
  5、搅拌和调配好的磁漆,应稠度适宜,喷涂后不发生流淌和下坠的现象。
  5. When mixing and dispensing the paint, the consistency should be appropriate, and no flowing or falling phenomena will occur after spraying.
  6、给彩钢瓦喷涂时,手握喷枪要稳,喷嘴与钢基材垂直。要求回旋转喷涂,注意搭接处颜色一致,薄厚均匀,要防止漏喷流淌。确保涂层完全闭合,轮廓清晰。
  6. When spraying colored steel tile, hold the spray gun steadily, and the nozzle is perpendicular to the steel substrate. Require rotary spraying, pay attention to the color of the lap is the same, thin and even thickness, to prevent leakage and spraying. Ensure that the coating is completely closed and the outline is clear.
  7、喷涂形成的涂层是粒状的表面,当设计要求涂层表面要平整光滑时,待喷涂完,应采用抹灰刀或其他工具进行抹平处理。
  7. The coating formed by spraying is a granular surface. When the design requires that the surface of the coating should be smooth and smooth, the plastering knife or other tools should be used to smooth it after spraying.
  二、事项:
                                      商河彩钢瓦
  II. Matters:
  1、磁漆的施工应确保各部分颜色一致,接茬平整。
  1. The construction of enamel should ensure that the color of each part is the same and the stubble is smooth.
  2、无漏涂、脱粉、明显裂缝等缺陷。
  2. No defects such as leak coating, dedusting and obvious cracks.
  3、油漆涂层与彩钢瓦基材之间,应粘牢固,无脱落,空鼓现象。
  3. Between the paint coating and the base material of the coloured steel tile, it should be firmly adhered, without falling off and empty drum phenomenon.
  4、应从上到下施工。
  4. Construction should be carried out from top to bottom.
  5、注意别污染太阳热水器、墙体竹墙板等成品。
  5. Be careful not to pollute finished products such as solar water heaters and bamboo wall panels.
  彩钢瓦磁漆的喷涂注意喷涂均匀,并及时作出检查,确保涂得符合施工要求,严格对涂料做出合理的配比,保持喷涂的平整,便于下一步生产。
  The spraying of color steel tile magnet paint should be uniform and checked in time to ensure that it meets the construction requirements, make a reasonable proportion of the paint strictly, keep the spraying smoothly and facilitate the next production.